Difference between revisions of "Team:Nagahama/Experiments"

(→‎Confirmation of anti-mold and antibocatrial activities of geraniol and farnesol)
(→‎Geraniol production)
Line 104: Line 104:
  
 
Geraniol is generated through GPP hydrolysis by geraniol synthase. A MEP pathway has been shown to synthesize IPP and DMAPP efficiently in ''E. coli''. ''E. coli'' engineered with Geraniol production device (BBa_K1653027) showed different smell as compared with the counterpart control (pSB1C3) and the original strain JM109. This result was obtained by the double blind test following the questionnaire survey. And then we tried to detect that the geraniol generated by engineered ''E. coli'' by GC and GC-MS. Geraniol was not detected. These results may suggest that ''E. coli'' with Geraniol production device produces less than the lowest limit detected by GC and GC-MS.
 
Geraniol is generated through GPP hydrolysis by geraniol synthase. A MEP pathway has been shown to synthesize IPP and DMAPP efficiently in ''E. coli''. ''E. coli'' engineered with Geraniol production device (BBa_K1653027) showed different smell as compared with the counterpart control (pSB1C3) and the original strain JM109. This result was obtained by the double blind test following the questionnaire survey. And then we tried to detect that the geraniol generated by engineered ''E. coli'' by GC and GC-MS. Geraniol was not detected. These results may suggest that ''E. coli'' with Geraniol production device produces less than the lowest limit detected by GC and GC-MS.
 +
 +
 +
[[File:Nagahama_SDS-PAGE.jpg|200px|Analyzed aspartase by E. coli BL21 and E. coli BL21/BBa_K1342001 by SDS-PAGE ,37℃ for 0,6 hr Lane:1,10 Protein Marker(Precision Plus Protein Standards (BIO-RAD)) Lane:2,3 E. coli JM109 Lane:4,5 E. coli JM109/BBa_K1342001 Lane:6,7 E. coli JM109/BBa_K1342001 (Additon of cadmium ion 100μM) Lane:8,9 E. coli JM109/BBa_K1342001 (Additon of cadmium ion 100μM and IPTG 1mM) respectively. OD600=0.74 CdCl2 100μM/IPTG 1mM AspA has 1482bp. It is about 54kDa.]]
  
  

Revision as of 05:49, 18 September 2015

Team Nagahama banner.jpg

Result and Discussion

Confirmation antibacterial activity of each volatile substances derived from plant

First, we examined our working hypothesis to “Flavorator” that the volatile gaseous substances from plants’ origin can show either the antibacterial or bacteriostatic activity in a box like “KOZOKO”. The results clearly showed that all the volatile substances of wasabi（Japanese horse radish）, rose, garlic and onion had antibacterial properties. In the literatures, wasabi, rose, garlic and onion have antibacterial volatiles, such as allyl isothiocyanate (wasabi), geraniol (rose),allicin (garlic), and lachrymatory-factor (onion). These antibacterial volatiles are produced after complicated pathways, so for their syntheses, various enzymes are required. Then, we searched metabolic pathways in E. coli, in which antibacterial volatiles can be either end products or intermediates. The search hit the geraniol. In E. coli, a precursor of geraniol, geranyl diphosphate (GPP), is synthesized. If we can successfully operate one enzyme to E. coli, it may synthesize geraniol using geranyl diphosphate as a precursor. In this context, we designed our system for establishing the concept of “Flavorator” to build up a brand-new biosynthetic pathways, in which geraniol is produced in the E. coli. In doing so, we transfered the three types of genes listed below to create the hyper-producer E. coli of geraniol.


We examined our working hypothesis to “Flavorator” that the volatile gaseous substances from plants’ origin can show either the antibacterial or bacteriostatic activity in a box like Kozoko.

Preventive effect of grated Wasabi root

Protocl here

Garlic was known to produce its flavorous substance (alicin) to suppress unwanted microbial growth. We checked the effect of volatile substance, whether it is effective to prervent mean deay or not. The left figure (A) shows that the pink color of the fresh pork meat was not changed. The right one (B) shows that the color of the pork meat was changed from pink to brown. Based on these observations, grated garlc has the preventive(s) to protect the pork's decay, possibly by releasing the antibacterial substances from the garlic.

Left figure (A): the grated garlic paste was put in a small box and it was put in a plastic cage with the separation from the the pork meat without direct contact. Right figure (B): the above treatment was not done. These pork meats in a plastic cage were left in the box at 18℃ for 2 months. Lef t pork (A) didn’t change the color. Right pork (B) changed the color from pink to brown.

Preventive effect of grated Wasabi root

Protocl here

grated Wasabi root produced its fragrances to suppress unwanted microbial growth. We spread the wasabi grated on the rice cake. The rice cake didn’t change the color. We found from this result that fragrance of plants have antibacterial volatiles.

Fig:The grated Wasabi root paste was put aside of rice cake in a plastic box without direct contact between rice cake and Wasabi root paste. These boxes were kept at 18℃ for 2 month. The rice cake in figure (A) didn’t change the overall state, while rice cake in figure (B) had mold. (A), plus Wasabi root paste; (B) minus Wasabi root paste.

Confirmation of anti-mold and antibocatrial activities of geraniol and farnesol

Protocl here

Grated roses are known to produce its fragrances to suppress unwanted microbial growth. There are case that the fragrances from plants have antibacterial volatiles.


fig1：Storage of English bread by geraniol. A: ddH2O（300 μl）, B: geraniol（300 μl of geraniol solution was spotted on the cotton）. Chopsticks dipped in suspension of mold was put in the center of the bread. These boxes were kept for 35 days at room temperature.


阻止円実験.jpg
Fig. 2：Effect of geraniol for growth of Bacillus subtilis ver. Natto (Chassie) (A and B) and E. coli (C and D). A, ddH2O（300 μl）; B, geraniol（300 μl）. Geraniol was put in the center of the paper of the plate cover without direct contact with the bacteria. The dishes were incubated for 21 hours at 37 ℃. Growth inhibition circle was not observed on the plate without geraniol (A), while inhibition circle was observed on the plate with geraniol (B). The result shows that Bacillus subtilis ver. natto can't grow in the presence of geraniol. C, ddH2O（300 μl）; D, geraniol（300 μl）. Geraniol was put in the center of the paper of the plate cover without direct contact with the bacteria. The dishes were incubated 21 hours at 37 ℃. Growt inhibition circle didn’t exist on the medium(C), and Inhibition circle existed on the medium(D), suggesting that Bacillus subtilis ver. natto can't cultured at high concentration of geraniol. Comparison of the B and D（Chassis：Bacillus subtilis ver. natto and E. coli） Inhibition circle of Bacillus subtilis ver. natto(B) is brighter than the inhibition circle of E. coli(D), suggesting that Bacillus subtilis ver. natto is lower resistance to geraniol than E. coli. This experiment indicate that geraniol might be the effect of suppressing the growth of bacteria, and there might be a difference in the resistance of geraniol by bacteria.


fig3：Antibacterial confirmation of farnesol Comparison of the A and B（Chassis：E. coli） A：ddH2O（300 μl）B：farnesol（stock solution, 300 μl） Incubation：21 hours Temperature：37 ℃ Farnesol is released toward the center of the plate. Inhibition circle didn’t exist on the medium(A), and Inhibition circle didn’t exist on the medium(B), suggesting that E. coli can cultured at high concentration of farnesol. Comparison of the C and D（Chassis：Bacillus subtilis ver. natto） C：ddH2O（300 μl）D：farnesol（stock solution, 300 μl） Incubation：21 hours Temperature：37 ℃ Farnesol is released toward the center of the plate. Inhibition circle didn’t exist on the medium(C), and Inhibition circle existed on the medium(D), suggesting that Bacillus subtilis ver. natto can't cultured at high concentration of farnesol. Comparison of the B and D（Chassis：E. coli and Bacillus subtilis ver. natto） Inhibition circle was only present on Medium of Bacillus subtilis ver. natto(D), suggesting that Bacillus subtilis ver. natto is lower resistance to farnesol than E. coli. This experiment indicate that farnesol might be the effect of suppressing the growth of bacteria, and there might be a difference in the resistance of farnesol by bacteria.


Increasing in the amount of terpenoid's precursors

パーツ画像 MEP .png terpenoid's precursors device ([http://parts.igem.org/wiki/index.php?title=Part:BBa_K1653024 BBa_K1653024])

We want to make the E.coli produces farnesol and geraniol which are one of the terpenoids. To produce great quantity of terpenoids they need many terpene precursor. E. coli produces a small amount of the terpene precursor in MEP pathway. In MEP pathway, there are four enzymes (ispD, ispf, idi, dxs) which are speed limiting enzyme for terpenoids precursors produce in E. coli. In order to create a high-yield strains producing IPP and DMAPP, we exogenously engineer to superimpose these genes into E. coli to create strains overproducing IPP and DMAPP in a MEP pathway.To confirm increased production of terpene precursors by Terpene precursor mass-production device. we put attention on ubiquinone. Ubiquinone 8 is made from Farnesyl diphosphate (FPP) which is one of the terpene precursors . quinone is one of the electron carrier present in the cell membrane of prokaryotes. And also they glow when exposed to UV rays.In the measurement of production of quinone it was measured by thin-layer chromatography. (TLC silica gel)

Result: The figure on the left is analysis of ubiquinone 8 by thin-layer chromatography. Right lane is JM109 /Terpene precursor mass-production device with IPTG Left lane is JM109/Terpene precursor mass-production device IPTG minus . Both it was 2μl spot. The right of the figure,Estimation of ubiquinone-8 content instead Each intensity of spots indicating the content of ubiquinone-8 From two figures, those which are overexpressed in reintroduced to E. coli four genes, it is better to have overexpressed were many production of ubiquinone 8 as compared with those that do not overexpress

Discussion: From this result, the amount of ubiquinone 8 of the final material by the increased amount of terpene precursors is increased by re-introducing the four genes are over-expressed in E. coli. Therefore, it considered could strengthen the MEP pathway.
○protocol here

  • Analysis of ubiquinone-8 synthesized by
    E. coli JM109/[http://parts.igem.org/wiki/index.php?title=Part:BBa_K1653025 BBa_K1653025]
     by thin-layer chromatography (TLC) Right lane: IPTG Left lane: IPTG minus
  • Estimation of ubiquinone-8 content in spot Each intensity of spots indicating the content of ubiquinone-8

Produce of Geraniol and Farnesol

Geraniol production

Geraniol production device ([http://parts.igem.org/wiki/index.php?title=Part:BBa_K1653025 BBa_K1653027])
パーツ画像 GES.png


Geraniol is generated through GPP hydrolysis by geraniol synthase. A MEP pathway has been shown to synthesize IPP and DMAPP efficiently in E. coli. E. coli engineered with Geraniol production device (BBa_K1653027) showed different smell as compared with the counterpart control (pSB1C3) and the original strain JM109. This result was obtained by the double blind test following the questionnaire survey. And then we tried to detect that the geraniol generated by engineered E. coli by GC and GC-MS. Geraniol was not detected. These results may suggest that E. coli with Geraniol production device produces less than the lowest limit detected by GC and GC-MS.


Analyzed aspartase by E. coli BL21 and E. coli BL21/BBa_K1342001 by SDS-PAGE ,37℃ for 0,6 hr Lane:1,10 Protein Marker(Precision Plus Protein Standards (BIO-RAD)) Lane:2,3 E. coli JM109 Lane:4,5 E. coli JM109/BBa_K1342001 Lane:6,7 E. coli JM109/BBa_K1342001 (Additon of cadmium ion 100μM) Lane:8,9 E. coli JM109/BBa_K1342001 (Additon of cadmium ion 100μM and IPTG 1mM) respectively. OD600=0.74 CdCl2 100μM/IPTG 1mM AspA has 1482bp. It is about 54kDa.


Fig.8 Questionnaire survey on smell strength of culture medium. We prepared two labeled culture media, "A" and "B", and asked twenty persons which medium smelled strongly. The medium labeled "A" was WT (JM109) or recombinant (JM109/empty vector), and the medium labeled "B" was recombinant (JM109/GES). The twenty persons were selected at random from our college and not informed which medium was recombinant (JM109/GES).
  • Fig.9 Result of questionnaire survey using WT and recombinant (JM109/GES). Out of 20 persons, two persons (10%) answered the medium A (WT) smelled stronger than the medium B (recombinant (JM109/GES)) and eighteen persons (90%) answered the medium B smelled stronger than the medium A. If we assume that both media smell equally, the probability that the medium A is selected in the questionnaire must be 0.5. From this assumption, p-value of this result was calculated using binomial test. Because the p-value was much smaller than the 5% significance level (0.0004025), the smell of recombinant (JM109/GES) is stronger than that of WT significantly. This result indicate that the recombinant (JM109/GES) synthesize geraniol.
  • fig10：The results of the questionnaire survey recombinant(JM109/Empty vector) was 25 % of the total, and recombinant(JM109/GES) was 75 % of the total, suggesting that recombinant(JM109/GES) was stronger smell than recombinant(JM109/Empty vector) . p-value is assumed fifty‐fifty that normally can occur, and the difference compared to that assumption. In this result, p-value is less than 0.05. This probability is beyond the range that can occur by chance. This experiment indicate that recombinant(JM109/GES) might being synthesize geraniol.

    • Farnesol production

    Farnesol production device ([http://parts.igem.org/wiki/index.php?title=Part:BBa_K1653025 BBa_K1653025])


    IspA+MEP.dev.jpg


    E. coli strain engineered with MEP pathway enzymes, ispDF, idi, and dxs , in combination with the enzyme gens, ispA, produced farnesol (Fig. 4B), which was detected by the Gas chromatography/Mas (Fig. 4A-G), having the same retention time as the farnesol chemical sample (Fig. 4A), while the counterpart control E. coli did not produce farnesol under the same conditions (Fig. 4C).　Neither E. coli engineered with MEP pathway enzymes only nor the one engineered ispA only showed any farnesol by the Gas chromatography/Mass (Figs. 4D and E). Farnesol is generated through hydrolysis of farnesyl diphosphate (FPP) by the endogenous phosphatases. Increase in farnesol should be associated with an increased intracellular FPP level. FPP is, in turn, converted from geranyl diphosphate (GPP), whose precursors are IPP and DMAPP. IPP and DMPP are end products of MEP pathway that exists in
    E. coli. Conversion to FPP from IPP or DMPP requires ispA (or m-ispA). Following this context, we speculate that E. coli could produce farnesol better than the counterpart control cells under the up-regulated cellular conditions of an increased intracellular MEP pathway enzymes by metabolic engineering in combination with the special enzyme that converts IPP or DMAPP into FPP.

    Gas Chromatography/Mass(GC/MS)


    Fig4:The farnesol standard solution (Ref) was used as a control. The peak corresponding to the farnesol standard at 8.5 min is indicated by an arrow. The peak at 8.5 min was applied to GC/MS. The farnesol standard solution (Ref) was used as a control. E. coli JM109([http://parts.igem.org/wiki/index.php?title=Part:BBa_K1653025 BBa_K1653025]) were compared with respect to farnesol formation using GC-MS. The fagment patarn is Similar with Ref.

    Efficient export of geraniol from E. coli to the media

    We introduce an activator gene of AcrAB-TolC efflux pump (marA) to release the geraniol from the cells and increase the content in the media that shows increase these flavors in the "Flavolator". In our study, we confirmed that overexpressing of marA gives host E. coli high resistance against geraniol and reduce intracellular geraniol concentration.
    MarA dev.png[http://parts.igem.org/wiki/index.php?title=Part:BBa_K1653020 BBa_K1653020]

    Fig. 1: Intracellular geraniol concentrations of E. coli JM109 (WT) and its overexpressing of marA strain, E. coli JM109 (marA).
    In this figure, intracellular content of geraniol was less in the strain E. coli JM109 (marA) than the strain E. coli JM109 (WT). The concentrations of intracellular geraniol from E. coli JM109 (marA) was 42.9 μg/ml, which was 40% lower than that from of E. coli JM109 (WT), 72.2 μg/ml. This figure is suggesting that internalized geraniol could be more efficiently exported through AcrAB-TolC efflux pump following the presumed activation of this gene by introducing the activator marA gene.

    Enhancement of geraniol resistance

    MarA dev.png[http://parts.igem.org/wiki/index.php?title=Part:BBa_K1653020 BBa_K1653020]

    Fig. 2: Colony formation efficiencies of E. coli JM109 engineered with marA on geraniol overlaid plates.
    E. coli JM109 and E. coli JM109 (marA) were spotted on LBGMg agar plates in serial ten-fold dilutions (10⁻¹～10⁻⁵), overlaid with 1.0 % (V/V)　geraniol hexane solution (geraniol solution), and incubated at 30°C for 24 h. This figure shows that E. coli JM109 (marA) cells that overexpress the marA product is more survived on 1.0 % geraniol solution overlay plates than the counterpart control E. coli JM109 wild type cells.
    Fig. 3: Comparison of colony numbers after addition of 0.5 %( V/V) geraniol hexane solution (geraniol solution).
    Time interval for treatment was set every 1 hour from 1 hour to 4 hours. A: E. coli JM109 (WT) + hexane; B: E. coli JM109 (marA) + hexane; C: E. coli JM109 (WT) + 0.5 % geraniol solution; D: E. coli JM109 (marA) + 0.5 % geraniol solution. As shown in Figs. 2 A and B, treatment with hexane of E. coli JM109 (WT) and of E. coli JM109 (marA) showed similar colony numbers during these treatment intervals to those of time zero. This result suggests that hexane at this concentration and duration of time for 4hours did not affect both cell growth. In contrast, treatment with geraniol of E. coli JM109 (WT) and of E. coli JM109 (marA) showed toxicities to both strains (Figs. 3 B, C and D). If we watch the colony numbers carefully, E. coli JM109 (marA) had more than E. coli JM109 (WT) during these treatment intervals ((Figs. 3 C and D). These results demonstrate that toxicity of the geraniol was less to the strain E. coli JM109 (marA) than the strain E. coli JM109 (WT).